Methyl 3-[(dimethoxyphosphinyl)oxy]crotonate SDS
SECTION 1: Identification of the substance/mixture and of the company/undertaking
Product identifier
- Product name： Methyl 3-[(dimethoxyphosphinyl)oxy]crotonate
- CAS： 298-01-1
Relevant identified uses of the substance or mixture and uses advised against
- Relevant identified uses： For R&D use only. Not for medicinal, household or other use.
- Uses advised against： none
Company Identification
- Company：Chemicalbook.in
- Address：5 vasavi Layout Basaveswara Nilayam Pragathi Nagar Hyderabad, India -500090
- Telephone：+91 9550333722
SECTION 2: Hazards identification
Classification of the substance or mixture
Acute toxicity - Category 2, Oral
Acute toxicity - Category 2, Dermal
Hazardous to the aquatic environment, short-term (Acute) - Category Acute 1
GHS label elements, including precautionary statements
-
Pictogram(s)
- Signal word Danger
H300 Fatal if swallowed
H310 Fatal in contact with skin
H400 Very toxic to aquatic life
P264 Wash ... thoroughly after handling.
P270 Do not eat, drink or smoke when using this product.
P262 Do not get in eyes, on skin, or on clothing.
P280 Wear protective gloves/protective clothing/eye protection/face protection/hearing protection/...
P273 Avoid release to the environment.
P301+P316 IF SWALLOWED: Get emergency medical help immediately.
P321 Specific treatment (see ... on this label).
P330 Rinse mouth.
P302+P352 IF ON SKIN: Wash with plenty of water/...
P316 Get emergency medical help immediately.
P361+P364 Take off immediately all contaminated clothing and wash it before reuse.
P391 Collect spillage.
P405 Store locked up.
P501 Dispose of contents/container to an appropriate treatment and disposal facility in accordance with applicable laws and regulations, and product characteristics at time of disposal.
Other hazards which do not result in classification
no data available
SECTION 3: Composition/information on ingredients
Substance
- Chemical name: Methyl 3-[(dimethoxyphosphinyl)oxy]crotonate
- Common names and synonyms: Methyl 3-[(dimethoxyphosphinyl)oxy]crotonate
- CAS number: 298-01-1
- EC number: 206-051-7
- Concentration: 100%
SECTION 4: First aid measures
Description of necessary first-aid measures
Fresh air, rest. Refer immediately for medical attention. See Notes.
Remove contaminated clothes. Rinse and then wash skin with water and soap. Wear protective gloves when administering first aid. Refer immediately for medical attention.
Rinse with plenty of water (remove contact lenses if easily possible).
Rinse mouth. Give a slurry of activated charcoal in water to drink. Refer immediately for medical attention. See Notes.
Most important symptoms/effects, acute and delayed
This material is super toxic; the probable oral lethal dose for humans is less than 5 mg/kg, or a taste (less than 7 drops) for a 150-lb. person. It has direct and immediate effects whether it is swallowed, inhaled, or absorbed through the skin. (EPA, 1998)
Indication of immediate medical attention and special treatment needed, if necessary
Treatment is the same as that for poisoning by other organic phosphorus cmpd ... The beneficial effects of oximes in people poisoned by mevinphos have been noted in several cases ... but not in all ... The importnace of thorough bathing is emphasized by a case in which continuing illness suggested continuing dermal absorption.
SECTION 5: Firefighting measures
Suitable extinguishing media
If material is on fire or involved in a fire: Do not extinguish fire unless flow can be stopped. Use water in flooding quantities as fog. Solid streams of water may be ineffective. Cool all affected containers with flooding quantities ofwater. Apply water from as far a distance as possible. Use foam, dry chemical, or carbon dioxide. keep run-off water out of sewers and water sources.
Specific hazards arising from the chemical
Fire may produce irritating or poisonous gases. Runoff from fire control may give off poisonous gases and also cause pollution. When heated to decomposition, it emits toxic fumes of phosphorus oxides. Avoid strong oxidizers. Avoid temperatures above 77-86F, sources of heat, fire, free flames or spark-generating equipment. (EPA, 1998)
Special protective actions for fire-fighters
Wear self-contained breathing apparatus for firefighting if necessary.
SECTION 6: Accidental release measures
Personal precautions, protective equipment and emergency procedures
Avoid dust formation. Avoid breathing mist, gas or vapours.Avoid contacting with skin and eye. Use personal protective equipment.Wear chemical impermeable gloves. Ensure adequate ventilation.Remove all sources of ignition. Evacuate personnel to safe areas.Keep people away from and upwind of spill/leak.
Environmental precautions
Personal protection: chemical protection suit including self-contained breathing apparatus. Do NOT let this chemical enter the environment. Do NOT wash away into sewer. Collect leaking liquid in sealable containers. Absorb remaining liquid in sand or inert absorbent. Then store and dispose of according to local regulations.
Methods and materials for containment and cleaning up
If phosdrin is spilled or leaked ... collect for reclamation or absorb in vermiculite, dry sand, earth or similar material.
SECTION 7: Handling and storage
Precautions for safe handling
Handling in a well ventilated place. Wear suitable protective clothing. Avoid contact with skin and eyes. Avoid formation of dust and aerosols. Use non-sparking tools. Prevent fire caused by electrostatic discharge steam.
Conditions for safe storage, including any incompatibilities
Separated from food and feedstuffs and strong oxidants. Keep in a well-ventilated room. Store in an area without drain or sewer access. Provision to contain effluent from fire extinguishing.Rooms used for storage only should be soundly constructed & fitted with secure locks. Floors should be kept clear & pesticides clearly identified. If repacking is carried out in storage rooms, adequate light should be available; floors should be impervious & sound . Pesticides
SECTION 8: Exposure controls/personal protection
Control parameters
| Component | Methyl 3-[(dimethoxyphosphinyl)oxy]crotonate |
|---|---|
| CAS No. | 298-01-1 |
|
Recommended Exposure Limit: 10 Hr Time-Weighted Avg: 0.01 ppm (0.1 mg/cu m), skin. Recommended Exposure Limit: 15 Min Short-Term Exposure Limit: 0.03 ppm (0.3 mg/cu m), skin. |
no data available
Appropriate engineering controls
Ensure adequate ventilation. Handle in accordance with good industrial hygiene and safety practice. Set up emergency exits and the risk-elimination area.
Individual protection measures, such as personal protective equipment (PPE)
Wear tightly fitting safety goggles with side-shields conforming to EN 166(EU) or NIOSH (US).
Wear fire/flame resistant and impervious clothing. Handle with gloves. Gloves must be inspected prior to use. Wash and dry hands. The selected protective gloves have to satisfy the specifications of EU Directive 89/686/EEC and the standard EN 374 derived from it.
If the exposure limits are exceeded, irritation or other symptoms are experienced, use a full-face respirator.
no data available
SECTION 9: Physical and chemical properties and safety characteristics
-
Physical state：
Mevinphos is a pale yellow to orange liquid, with a weak odor. Used as an insecticide and acaricide on vegetables, alfalfa, deciduous fruits and nuts. (EPA, 1998) May be found in the form of a dry mixture where the liquid is absorbed onto a dry carrier.
-
Colour：
PALE YELLOW LIQUID
-
Odour：
Weak odor
-
Melting point/freezing point：
44.4 to 70° F trans isomer / cis isomer (EPA, 1998)
-
Boiling point or initial boiling point and boiling range：
243.4°C at 760mmHg
-
Flammability：
Class IIIB Combustible Liquid: Fl.P. at or above 200°F.
-
Lower and upper explosion limit/flammability limit：
no data available
-
Flash point：
115.1°C
-
Auto-ignition temperature：
no data available
-
Decomposition temperature：
300°C
-
pH：
no data available
-
Kinematic viscosity：
no data available
-
Solubility：
Miscible (NIOSH, 2016)
-
Partition coefficient n-octanol/water：
log Kow = 0.13
-
Vapour pressure：
0.0323mmHg at 25°C
-
Density and/or relative density：
1.216g/cm3
-
Relative vapour density：
no data available
-
Particle characteristics：
no data available
SECTION 10: Stability and reactivity
Reactivity
Decomposes on heating. This produces toxic and corrosive fumes including phosphoric acid and phosphorus oxides. Reacts violently with strong oxidants. This generates fire and explosion hazard. Attacks iron, stainless steel, brass, some forms of plastic, rubber and coatings.
Chemical stability
Moderately stable in neutral soln, ... remained effective biologically after standing 7 days
Possibility of hazardous reactions
Organophosphates, such as MEVINPHOS, are susceptible to formation of highly toxic and flammable phosphine gas in the presence of strong reducing agents such as hydrides. Partial oxidation by oxidizing agents may result in the release of toxic phosphorus oxides.
Conditions to avoid
no data available
Incompatible materials
Contact with strong oxidizers may cause fires and explosions.
Hazardous decomposition products
Toxic gases and vapors ( ... phosphoric acid mist and carbon monoxide) may be released in a fire involving phosdrin.
SECTION 11: Toxicological information
Acute toxicity
- Oral: LD50 Mouse oral 7-18 mg/kg
- Inhalation: LC50 Rat female inhalation 14 ppm/1 hr
- Dermal: LD50 Rabbit percutaneous 16-34 mg/kg
Skin corrosion/irritation
no data available
Serious eye damage/irritation
no data available
Respiratory or skin sensitization
no data available
Germ cell mutagenicity
no data available
Carcinogenicity
A4; Not classifiable as a human carcinogen.
Reproductive toxicity
no data available
STOT-single exposure
no data available
STOT-repeated exposure
no data available
Aspiration hazard
no data available
SECTION 12: Ecological information
Toxicity
- Toxicity to fish: LC50 Lepomis macrochirus 70 ug/l/96 hr /Static bioassay
- Toxicity to daphnia and other aquatic invertebrates: no data available
- Toxicity to algae: no data available
- Toxicity to microorganisms: no data available
Persistence and degradability
In laboratory studies in Chehalis clay loam, 95% of the applied mevinphos degraded in 1 day(1). An enzyme was found to be responsible for the degradation which was heat labile(1). Another investigator, who did hydrolysis studies of mevinphos in water, reported that mevinphos degradation in soil was generally rapid with a half-life of 2-12 hr(2). This degradation rate, which is much more rapid than the rate of hydrolysis in water at pH 9(2), is consistent with a microbially-mediated process(SRC).
Bioaccumulative potential
Using an estimated log Kow of -0.24(1), one would estimate a BCF of 0.4 for mevinphos using a recommended regression equation(2). This would indicate that mevinphos would not bioconcentrate in aquatic organisms. Bioaccumulation of mevinphos may be unlikely in some systems because it is metabolized in some animals(3).
Mobility in soil
The amount of mevinphos bound by soils increased with increasing orgainc content. ... soil moisture has a major influence on the availability and extractability of residues of organophosphorus pesticides ... because of competition between the insecticides and water for adsorption sites on clay particles. ... mevinphos /when compared to other organophosphorus pesticides/ 1.4-fold more active in moist soils than in dry soils. however, even though there is a major interaction between insecticides and water, it does not appear to move freely in soils with water, and loss by leaching does not appear to be a major factor. ...
Other adverse effects
no data available
SECTION 13: Disposal considerations
Disposal methods
The material can be disposed of by removal to a licensed chemical destruction plant or by controlled incineration with flue gas scrubbing. Do not contaminate water, foodstuffs, feed or seed by storage or disposal. Do not discharge to sewer systems.
Containers can be triply rinsed (or equivalent) and offered for recycling or reconditioning. Alternatively, the packaging can be punctured to make it unusable for other purposes and then be disposed of in a sanitary landfill. Controlled incineration with flue gas scrubbing is possible for combustible packaging materials.
SECTION 14: Transport information
UN Number
ADR/RID: UN2810 (For reference only, please check.)
IMDG: UN2810 (For reference only, please check.)
IATA: UN2810 (For reference only, please check.)
UN Proper Shipping Name
ADR/RID: TOXIC LIQUID, ORGANIC, N.O.S. (For reference only, please check.)
IMDG: TOXIC LIQUID, ORGANIC, N.O.S. (For reference only, please check.)
IATA: TOXIC LIQUID, ORGANIC, N.O.S. (For reference only, please check.)
Transport hazard class(es)
ADR/RID: 6.1 (For reference only, please check.)
IMDG: 6.1 (For reference only, please check.)
IATA: 6.1 (For reference only, please check.)
Packing group, if applicable
ADR/RID: I (For reference only, please check.)
IMDG: I (For reference only, please check.)
IATA: I (For reference only, please check.)
Environmental hazards
ADR/RID: Yes
IMDG: Yes
IATA: Yes
Special precautions for user
no data available
Transport in bulk according to IMO instruments
no data available
SECTION 15: Regulatory information
Safety, health and environmental regulations specific for the product in question
SECTION 16: Other information
Abbreviations and acronyms
- CAS: Chemical Abstracts Service
- ADR: European Agreement concerning the International Carriage of Dangerous Goods by Road
- RID: Regulation concerning the International Carriage of Dangerous Goods by Rail
- IMDG: International Maritime Dangerous Goods
- IATA: International Air Transportation Association
- TWA: Time Weighted Average
- STEL: Short term exposure limit
- LC50: Lethal Concentration 50%
- LD50: Lethal Dose 50%
- EC50: Effective Concentration 50%
References
- IPCS - The International Chemical Safety Cards (ICSC), website: http://www.ilo.org/dyn/icsc/showcard.home
- HSDB - Hazardous Substances Data Bank, website: https://toxnet.nlm.nih.gov/newtoxnet/hsdb.htm
- IARC - International Agency for Research on Cancer, website: http://www.iarc.fr/
- eChemPortal - The Global Portal to Information on Chemical Substances by OECD, website: http://www.echemportal.org/echemportal/index?pageID=0&request_locale=en
- CAMEO Chemicals, website: http://cameochemicals.noaa.gov/search/simple
- ChemIDplus, website: http://chem.sis.nlm.nih.gov/chemidplus/chemidlite.jsp
- ERG - Emergency Response Guidebook by U.S. Department of Transportation, website: http://www.phmsa.dot.gov/hazmat/library/erg
- Germany GESTIS-database on hazard substance, website: http://www.dguv.de/ifa/gestis/gestis-stoffdatenbank/index-2.jsp
- ECHA - European Chemicals Agency, website: https://echa.europa.eu/